"AOX-R" series products small part turn electric motor operated valve actuator are used to control valves with rotation of 0 °~270 °, such as ball valves, butterfly valves, flapper valves, louver valves, etc., which can be widely used in petroleum, chemical, water treatment and other industries. It uses 380VAC/220VAC/24VDC as the driving power, and the maximum output torque can reach 5000NM.
"AOX-R" series products Small Part Turn Electric Motor Operated Valve Actuator are used to control valves with rotation of 0 °~270 °, such as ball valves, butterfly valves, flapper valves, louver valves, etc., which can be widely used in petroleum, chemical, water treatment and other industries. It uses 380VAC/220VAC/24VDC as the driving power, and the maximum output torque can reach 5000NM.
"AOX-R" series Small Part Turn Electric Motor Operated Valve Actuator adopts potentiometer. The potentiometer is output as a feedback signal in the actuator and has three output terminals, of which pin ② is connected to the sliding arm of the potentiometer. ① When the pin is connected to the actuator open action, the resistance between the pin and the sliding arm decreases continuously at one end, while the pin ③ is connected to the sliding arm when the actuator closes action, the resistance between the pin and the sliding arm decreases continuously at one end. Use the handle to turn the valve to the fully open position, subject to the action of the limit switch. Use a multimeter to measure, and adjust the resistance of ② pin and ① pin on the terminal to 35 Ω - 60 Ω. If it is not correct, it can be adjusted by turning the potentiometer drive gear.
Torque range: |
30 ~ 5000NM; |
Switching time: |
20 ~ 200S; |
Weight: |
2.1 KGS ~ 68KGS |
Protection grade: |
IP67, (IP68 optional); |
Limit switch: |
2 * open / close, SPDT, 250V AC 10A; |
Output flange: |
bottom mounting dimension is in accordance with ISO5211 international standard; |
Lubrication: |
aluminum base grease (EP type); |
Motor: |
squirrel cage asynchronous click, insulation class H; |
Related humidity: |
<90%(25℃). |
Mounting Flange: |
(ISO 5211)F04/F05/F07/F10/F12/F14/F16 |
Display Mode: |
LCD, indication of opening(0-100%) and open/close fault. |
Control Mode: |
On-off signal control, Modulating (proportional regulation) control, Fieldbus Control etc. |
Type of On-off Signal: |
Contact signal. Pulse signal |
Type of Field-bus Signal: |
Modbus-RTU, Profibus-DP, etc. |
Local Controller: |
AOX remote control(Optional) |
Model |
Max output torque |
Operating Time 90° |
Drive shaft(mm) |
Power |
Rated current(A) |
Weight |
|
N·M |
( ?90°) |
Square |
Deep |
(W) |
220VAC/1ph |
(kg) |
|
AOX-R-003 |
30 |
20 |
11×11 |
15.5 |
8 |
0.25 |
2.1 |
AOX-R-005 |
50 |
30 |
14×14 |
18 |
10 |
0.24 |
3.6 |
AOX-R-008 |
80 |
30 |
14×14 |
18 |
10 |
0.26 |
3.6 |
AOX-R-010 |
100 |
30 |
17×17 |
22.5 |
15 |
0.40 |
4.6 |
AOX-R-015 |
150 |
40 |
17×17 |
22.5 |
15 |
0.42 |
4.6 |
AOX-R-020 |
200 |
30 |
22×22 |
26 |
60 |
0.28 |
13 |
AOX-R-030 |
300 |
30 |
22×22 |
26 |
60 |
0.32 |
13.4 |
AOX-R-040 |
400 |
30 |
22×22 |
26 |
60 |
0.34 |
13.8 |
AOX-R-060 |
600 |
40 |
27×27 |
32.5 |
60 |
0.35 |
14 |
AOX-R-080 |
800 |
40 |
27×27 |
32.5 |
90 |
0.56 |
14.3 |
AOX-R-100 |
1000 |
40 |
27×27 |
32.5 |
90 |
0.59 |
14.5 |
AOX-R-160 |
1600 |
60 |
Max Φ40 |
65 |
90 |
0.60 |
68 |
AOX-R-200 |
2000 |
60 |
Max Φ40 |
65 |
90 |
0.62 |
68 |
AOX-R-300 |
3000 |
120 |
Max Φ40 |
65 |
90 |
0.64 |
68 |
AOX-R-400 |
4000 |
200 |
Max Φ40 |
65 |
90 |
0.66 |
68 |
AOX-R-500 |
5000 |
200 |
Max Φ40 |
65 |
90 |
0.67 |
68 |
No. |
Option scheme |
Remark |
1 |
Heater |
AOX-R Series |
2 |
Water-proof actuator(IP68,10M,250HR) |
AOX-R Series |
3 |
Potentionmeter unit(1k-10k) |
Exceot AOX-R-003 |
4 |
Proportion control unit(Control signal 4-20mA DC/1-5V/10V) |
AOX-R Series |
5 |
Local control units (Local control open/stop/close optional switch, local/remote switch) |
Exceot AOX-R-003 |
6 |
Travel 120°, 180°,270° |
AOX-R Series |
7 |
Direct current motor(24VDC) |
AOX-R Series |
8 |
Electric current position sensor (Output 4-20mA DC) |
Exceot AOX-R-003 |
9 |
Self-reset when power failure |
AOX-R Series |
10 |
Quick opening(2.8s,5s,10s,15s) |
AOX-R Series |
Q: What payment methods your company accept?
A: We accept most of the payment methods,but maily accept T/T,L/C,Western Union.
Q: Can we have our logo or comany name to be printed on your AOX-R series water proof quarter turn electric actuators or package?
A :Sure. Your Logo could be printed on our products by sticker.
Q: How to order AOX-R series water proof quarter turn electric actuators?
A :Pease send us your purchase order by Email , or we can make you proforma invoice under your request.We need to know the following information for your order before sending you PI.
1) Product information Quantity, Specfcaton(Size, Material,Technological if needed and Packing requirements etc)
2) Delivery time required
3) Shipping information Company name, Street address,Phone &fax number, Destination seaport